What emission standards should be implemented for gas internal combustion engine generator sets

1. The fuel of the gas engine is mainly natural gas, and flammable gases such as oilfield associated gas, liquefied petroleum gas, and biogas can also be used.

2. The gas pin used should be dried and dehydrated to achieve no free water, ** and light oil, and its low calorific value should not be lower, the total sulfur content is greater than 480mg m3, Weichai diesel generator set, hydrogen sulfide content is not more than 20mg m3

3. In addition, the natural gas transmission pressure is within the range.

Gas generator sets.

Operational requirements of the unit.

a.When starting, step on it first.

Foot switch. Press the start button to drain the gas in the cylinder and turn it on again.

Gas valves. It is strictly forbidden to give gas first and then press the start button. When the start is unsuccessful or the fire is extinguished after starting, the gas valve should be closed immediately, the cause should be investigated, and the cylinder should be discharged.

Gas mixtures. After that, it will be restarted according to the prescribed procedures. After successful startup, the foot switch should be kicked off immediately.

b.When the machine is turned on, open the doors and windows and turn on the exhaust device until it stops.

c.When the operator is operating in the machine room, he should wear a safety helmet or helmet, and he cannot face it directly during the operation of the machine.

Explosion-proof doors should avoid high-speed rotating parts such as flywheels and should not be touched.

Exhaust pipes and other high-temperature parts.

d.During operation, if a gas leak is found, the operator should immediately unload the load and stop the machine for inspection.

e.When the unit is running, pay attention to the explosion-proof safety door of the gas engine, and once it bursts (its sound is loud), the gas source should be turned off immediately and the explosion-proof should be replaced.

rubber before restarting.

Gas generator sets have the advantages of wide output power range, reliable starting and operation, high power generation, light weight, small size, simple maintenance, low frequency noise, etc., generally they have the following three advantages:

First, the operating cost of gas generator set is low: new energy, waste to treasure and environmental protection and clean emissions have increasingly become the first choice of users.

Second, the starting performance of the gas generator set is good, and the success rate of starting is high. The time from successful cold start to full load is only 30 seconds, while the international regulation of diesel generators is 3 minutes after successful start-up with load. Gas turbine generator sets can guarantee the success rate of start-up in any ambient temperature and climate.

3. The noise of the gas generator set is low and the vibration is small. Because the gas turbine is rotating at high speed, it has very little vibration and better low-frequency noise than diesel generator sets.

Fourth, the flammable gas used in gas generator sets is a clean and cheap energy source.

Such as: oilfield associated gas, gas gas, junction gas, biogas, etc.

Generator sets fueled by them are not only reliable and low-cost, but also can turn waste into treasure without polluting. (Landfill power generation).