What should I do if the air energy heat pump water heater has condensate discharged and affects the

You draw a rope where the condensate droplets gather, and find a way to secure the end of the rope to the wall.

The condensation will flow down the rope to the wall, so you can rest assured that it won't get wet.

The wall is large, and that bit of moisture will evaporate quickly.

This sheet metal generally has holes, which can be installed with the water elbow on the market, and then sealed with glass glue, and the water elbow (water outlet) is discharged to the sewer pipe.

Attention should be paid to the installation location:

Provide sufficient space for installation and maintenance;

The air inlet and outlet are barrier-free and strong winds should not blow everywhere;

The support surface is flat, can bear the weight of the unit, can be installed horizontally, and will not increase noise and vibration;

The operating noise and exhaust air do not affect the neighbors;

There is no place for flammable gas leakage;

Convenient for installation of connecting pipes and places for electrical connections;

The unit can be installed on the balcony, roof, ground or any other place that is convenient for installation and reliable load-bearing;

places with good air circulation;

Places where there is no thermal radiation or other heat sources; Snow shelters should be set up in winter; In the near side of the air intake or exhaust outlet without obstruction;

Places where the exhaust outlet is not blown by strong winds; There should be drainage channels around the fuselage to drain condensate;

There should be enough space around the machine.

Installation in the following places may cause machine failure (if this cannot be avoided, please contact us).

Where there are mineral oils such as cutting engine oils; In places where there is a lot of salt in the air, such as the seaside; In hot spring areas, where corrosive gases such as sulfur gas are present; Factories and other places where the power supply voltage fluctuates severely; places such as cars or cabins; Kitchens and other places full of oil, gas and oil splashes; where there are strong electromagnetic waves; where flammable gases or materials are present; where acidic or alkaline gases evaporate; Other special environmental conditions.

Hello, this is easy to do. There is a condensate connection at the low end of the air energy host, you need to install a condensate pipe, and then connect the hose (length according to the actual situation) to lead to the place where the condensate can be directly discharged.

Make a simple funnel (like half of a mineral water bottle) and connect an air conditioner drain pipe to the right place.

There is no way, the condensate of the air conditioner is directly discharged outside, unless you add a section of condensate pipe, channel rainwater pipe.

When the air energy water heater heats water, the surface temperature of the fin heat exchanger is very low, and the water vapor in the surrounding air will condense into water on the surface of the heat exchanger.

The resulting condensate can be discharged from the bottom of the water heater to a designated location using a special device.

It is also possible to place an integral water tray at the bottom of the air energy water heater to collect and divert condensate.

There is a lot of dust and bacteria in the condensate, which is not drinkable, so it is recommended to drain it directly.

This thing is generally placed on the balcony or on the floor of the roof. For your problem is very easy to solve, make a drawer-type base drawer can be filled with water.

There is a condensate drainage hole at the bottom of the outer unit, and the water nozzle and water pipe are discharged into the sewer.

So there was a problem with the installation at that time, because it was easy to get the floor wet.

Treatment method of condensate in water heater.

1. The condensing gas water heater produces about a liter of water per hour when working in winter, and the water is mainly condensed by hydrogen in gas (CH4) and oxygen combustion during combustion.

Second, the condensate produced during the large fire in winter is correspondingly more due to the increase of gas consumption, and the fire power is less in summer.

3. It doesn't matter if there is no reserved condensate drainage pipe, there is not much water discharged for daily use, and it is enough to use a container to connect the water below.

When the Gree Air Energy Water Heater is working, condensate will be discharged from the bottom of the external unit. This is a normal phenomenon when the unit is running, not a fault, if necessary, you can contact the after-sales service to install the drain pipe.

The noise of air energy water heater is mainly due to the compressor or fan, if the noise is too loud, it is recommended to find the manufacturer's after-sales personnel to come to the door to detect whether there are some parts that are loose or not fixed.

Before leaving the factory, the manufacturer will conduct a noise test on the machine, and will enclose the compressor, and cover the inside of the water heater shell with a layer of sound-absorbing cotton, so as to ensure that the sound generated by the air energy water heater during operation is within the normal range.

In addition to the merchant to pay attention to when installing, the user should also do:

1. Reduce the impact of the noise of the main engine of the air energy water heater, such as the compressor and the silencer sleeve, and the fan adopts the silent type, that is, the low-noise air energy is selected as much as possible.

2. In addition to the good vibration reduction of the internal compressor base of the air energy water heater, the base of the heat pump should also have vibration reduction measures, in addition, the air energy water heater host should be as far away from the room as possible, or add a sound insulation screen between it and the adjacent room, but it should be noted that the sound insulation screen should not obstruct the circulation of ventilation airflow.

3. The main engine of the air energy water heater is arranged on the roof of the main building with the smallest influence surface. The entrance and exit from the building to the roof platform where the heat pump is located should be made of soundproof doors and soundproof suites, or there should be auxiliary rooms (such as pump rooms, power distribution rooms) and other partitions between the main engine of the air energy water heater and the core tube of the building.

4. The water pump is also the main source of noise, and the vibration and noise isolation of the water pump is equally important. If the water pump is placed indoors, it can not only prevent rain, but also sound insulation, and the pump room should be treated with sound absorption, such as the pump is placed outdoors, and the sound-absorbing data is pasted in the rain cover to reduce noise.

5. If the compressor is broken, the noise will become relatively loud, which will affect the normal use. If the compressor is running normally, if the installation is not scientific and unreasonable, it will also cause the compressor to be too noisy. For example, if the external unit is not placed horizontally during the installation process, it will lead to the collision between the working fluid copper pipe and the shell during operation, or the friction of the fan blades in the chassis, resulting in large noise, which will not only affect the rest of the surrounding residents, but also affect the service life of the unit and cause failure.

Only by carrying out correct and scientific installation can the noise generated during the operation of the unit be reduced, the normal operation of the unit can be guaranteed, and the impact of noise on the residents can be reduced.

That's condensation, which is normal in most cases.

An air source water heater, also known as a heat pump water heater, is a device that uses the heat pump principle to absorb heat from the air to make hot water. By allowing the working fluid to continuously complete the thermodynamic cycle process of evaporation (absorbing heat from the environment), compression, condensation (releasing heat), throttling, and re-evaporation, the heat in the environment is transferred to the water.

In layman's terms, it is a heating air conditioner that converts the indoor unit into a water tank. Its outdoor unit will work in the same way as the air conditioner when heating, and the internal temperature will be much lower than the environment. Moisture in the environment condenses in it during operation, producing water.

For the condensate generated by the unit during operation, the unit usually uses a heat exchange fan to dry it, and if there is too much condensate, it is discharged through the set drain.

There is a leak under the air source water heater unit, which generally occurs in the season when the weather is humid. It is normal for the condensate to be generated at a rate that exceeds the evaporation rate to form stagnant water discharge; In addition, when using an air source water heater in the north or in winter, the water will also come out when the unit is defrosted, which is a normal phenomenon.

For most models, water will not flow out of the unit if there is a tank leak (which is one of the reasons for the water coming out of the unit). Only when the weather is fine and the temperature is higher than 5, and a large amount of water continues to flow out under the unit, the possibility of water tank (water pipe) leakage should be considered, and professional maintenance personnel should be checked.

If there is water under the fan, it should be condensation, just like the air conditioner will have condensation, which is normal. It is also possible that the inner tank of the air source water heater is ruptured, if this is the reason, it is recommended that you find the professional after-sales team of the merchant to help repair it.