The cost of building a 500 square meter cold storage

The height of the refrigerator room of 500 is in square meters, so that the net cube is 1150 cubic meters. The refrigerator room is equipped with a 40 hp low-temperature unit, which is about 100,000.

According to the storage temperature, it can be divided into these types:

1. High-temperature small cold storage: mainly used to store fruits and vegetables, eggs, medicinal materials, wood preservation, drying, etc.

The temperature is usually 0 15 and is cooled by blowing air with a air cooler.

2. Medium temperature small cold storage: mainly used to store meat, aquatic products, poultry meat, etc.; The general storage temperature is -15 -18.

3. Low-temperature small cold storage: also known as freezing storage, freezing cold storage, freezing of food through air coolers or special freezing devices; The temperature is -18 -25. It is mainly used for quick-frozen food, industrial testing, medical treatment and other special purposes.

4. Quick-frozen small cold storage: quick-frozen cold storage, used for rapid freezing of food.

Notes:

1. The sampling tube should be more than 300mm away from the wall or ceiling as far as possible to avoid frost on the pipeline.

2. The side hole is opened, and the condensate is easy to be generated at the lower edge of the pipeline, and the side hole can avoid blocking the sampling hole after the condensate thaws.

3. The detection host is installed outside the cold storage, and the exhaust needs to be connected back to the inside of the cold storage.

4. The pipeline must be connected to the heater immediately at the position where it comes out of the cold storage to heat the air inside the pipeline, so that the pipeline outside the cold storage will not be affected by the cold air inside the cold storage and frozen.

Frozen pipes can cause a large amount of surface condensation due to high outside temperatures, resulting in freeze-thaw cycles, leading to possible health and safety risks.

To build a 500-square-meter cold storage, you need to provide the length, width and height of the cold storage, the installation environment, the type of storage goods, the temperature of the cold storage, the size of the compartment, whether to use polyurethane spraying or the library board, the amount of material, etc., in order to report accurate data, about 35-450,000 yuan of budget.

How big a cold storage to build, whether it is a small cold storage or a large cold storage, technicians need to go to the site for inspection, and civil work is more important. The ground should be dug down, plain soil, concrete, waterproofing, polyurethane, in concrete. The cold storage plate is inserted around the installation, and the cold storage plate is filled in the ground gap after the completion of the later period.

Cold storage should be built in a ventilated and convenient place. Cold storage is divided into different categories according to different uses: high-temperature fresh-keeping cold storage, low-temperature freezer, quick-frozen storage, cool storage, normal temperature storage, constant temperature storage, etc.

The cost of the civil part, the civil engineering ** and the normal building is also about the same, according to 1100 yuan square meters, the ground and wall to keep about 200 yuan square, no windows and doors, ** will not be higher than ordinary windows and doors.

For more information about the cost of cold storage, it is recommended to choose Guangxiang Refrigeration. Guangxiang cold storage uses high-quality double-sided color steel polyurethane cold storage boards, which occupies a small area and has good thermal insulation performance. At the same time, Guangxiang Refrigeration has advanced installation technology and strict quality assurance management.

Its control system components are produced by international and domestic famous brand manufacturers, Chinese and foreign high-quality brand compressors, with stable quality, excellent performance, high efficiency and other characteristics, customized cold storage for customers. Professional maintenance team provides door-to-door maintenance services to eliminate worries for customers. [Click to get the cold storage cost plan].

The quick-freezing room is so big: the height is 200 net cubes. The height of the refrigerator room of 500 is also there, so that the net cubic is 1150 cubic meters. A 40 hp cryogenic unit in the refrigerator is sufficient. Yours is about 100,000.

Beijing Brose Refrigeration Equipment**** 010-60215954 64 Miss Feng, welcome your call, we will serve you wholeheartedly!

Will Jinan be so hot?

Hello! Kiss! Building a 100 square meter cold storage requires 8-90,000 yuan The construction of small cold storage is generally about 20 cubic meters to 100 cubic meters, and the cost of building a 20 cubic meter cold storage is about 2-30,000, and the cost of building a 50 cubic meter cold storage is about 4-50,000, and the cost of 100 cubic meters of cold storage is about 8-90,000.

The cost usually includes the following aspects: 1, the cost of the library body such as the polyurethane board of the library body, the reinforcement of beams and columns, the top and the bottom and so on. If some surfaces require structures such as foundation concrete, a certain party is responsible for the specific situation.

2. Unit cost cooling compressor unit - a very important part for cold storage. 3. Accessories such as cold storage doors, air coolers, cooling towers, pumps, pipes, liquid storage tanks, separators, lines, switches, ......Wait a minute. 4. Miscellaneous expenses such as transportation, defrosting and drainage system, labor and other costs.

Finally, the estimated cost of cold storage is obtained.

The construction of 1,000 square meters, 5 meters high cold storage is about 600,000 to 1.5 million, and the specific ** is not fixed, which is related to the following factors;

The calculation of cold storage is not calculated by square meters or cubes, but according to the size you want to do, you will be given the unit, library board, electric control box, pipes, wires and so on. If the temperature requirements of the cold storage of the same size are different, the lower the temperature, the higher the temperature. You can refer to the small cold storage with a fresh-keeping temperature, such as about 20 cubic meters, and the medium and high-end equipment used in it, about twenty or thirty thousand is enough, and the unit price of the cubic meter is about 1500, but if you make a 50 cubic meter does not need seventy or eighty thousand, but forty or fifty thousand is enough, then the cubic unit price is only about 1000.

Because, no matter how small the cold storage is, all the equipment is indispensable, so this is why the larger the cold storage, on the contrary, the flat flat unit price of the square unit price cubic unit price is lower, maybe only two or three hundred and one cubic meters. Therefore, the most direct way is to hit the refrigeration company, and direct consultation is the most reliable and stable!

Normally, the cost of cold storage is 500 yuan, if it is necessary to build 1,000 square meters, it is normally 500,000 yuan.

Dear, hello, how much is a square meter of cold storage construction? The following ** is for reference only, the specific cost of cold storage should be determined according to the site conditions and design requirements. 1. For fresh-keeping cold storage with a scale of about 10-50 square meters, the estimated cost per square meter is about 3000-1400; 2. For fresh-keeping cold storage with a scale of about 100-500 square meters, the estimated cost per square meter is about 1300-900; 3. The scale of fresh-keeping cold storage is about 1000-5000 square meters, and the estimated cost per square meter is about 1000-800; In the same case, the larger the scale of cold storage construction, the lower the cost per square meter.

According to the needs of different users, the cost of cold storage will vary greatly, for example, in the case of 100 square meters of fresh cold storage cost of 100,000, the cost of 100 square meters of controlled atmosphere cold storage may need 300,000. Therefore, the construction of large-scale cold storage requires users to provide detailed construction parameters of cold storage, preliminary plan and drawing design of cold storage. In particular, the design of the preliminary drawings is very important.

The early design should not only consider the cost reduction, but also consider the factors such as energy saving and consumption reduction, convenient maintenance, etc., of course, this is only the estimated cost, in the actual situation, the cost of cold storage still needs to be calculated by determining the cold storage design scheme, according to the list of main materials and auxiliary materials of the cold storage project, the estimate is for reference only.

Summary. How much does it cost to build a 300 square meter cold storage? This includes the labor cost of the warehouse and refrigeration equipment.

Hello dear, if you want to build 300 square meters of cold storage now, let me talk about my personal experience, 300 square meters of cold storage first need to purchase refrigeration equipment, some decorative materials and building materials inside the cold storage, and cold to divide, which requires a certain amount of labor costs, the current market, cold purchase of refrigeration equipment 300 square meters need RMB between 500,000 and 550,000 yuan installation fees, labor costs should be more than 50,000 yuan.

How much does it cost to build a 300 square meter cold storage? This includes the labor cost of the warehouse and refrigeration equipment.

How much does it cost to build a 300 square meter cold storage? Including the warehouse and refrigeration equipment labor costs Hello dear, if you want to build 300 square meters of cold storage now, let me talk about my personal experience, 300 square meters of cold storage first need to purchase refrigeration equipment, some decorative materials and building materials inside the cold storage, and cold to divide, which requires a certain amount of labor costs, the current market, cold purchase of refrigeration equipment 300 square meters need RMB between 500,000 and 550,000 yuan installation fees, The total labor cost should be more than 50,000 yuan, I hope it can help you.

If my answer is helpful to you, please give a thumbs up (in the lower left corner), I look forward to your like, your efforts are very important to me, and your support is also the motivation for my progress. Finally, I wish you good health and a good mood!

Summary. 2.Device Configuration:

1) Cold storage structure: The cold storage structure generally includes external walls, interior walls and roofs. (2) Cold storage door:

Cold storage doors can be divided into sliding doors, rolling doors and folding doors. (3) Cold storage air conditioning: Cold storage air conditioning equipment is mainly used to adjust the temperature and humidity in the cold storage.

4) Cold storage monitoring: The cold storage monitoring system generally includes temperature sensors, humidity sensors, smoke sensors, etc., which can monitor the temperature, humidity and smoke concentration in the cold storage in real time. It's almost more than 100.

Hello, dear <>

According to the questions you provide, we will find the following for you: the total investment of 2500 square meters of cold storage is about 1 million yuan, and the specific investment amount depends on the scale, type, and equipment configuration of the cold storage.

Machinery and equipment, with the total investment in installation.

Can you recommend the manufacturer to me?

Determine the power supply and exhaust systems for cold storage, as well as the cooling system for cold storage; Determine the temperature control system for cold storage, as well as the shelving and shelving system for cold storage; Determine the alarm system of the cold storage, as well as the control system of the cold storage; Determine the safety measures for cold storage, as well as maintenance, cleaning, and upkeep of cold storage.

Oh. You say that 1 million can be completed with a total investment.

1.Cold storage type: Cold storage can be divided into room temperature cold storage, frozen cold storage and refrigerated cold storage.

Room temperature cold storage usually refers to cold storage with a temperature of not less than 10, which is often used to store fruits and vegetables, meat, aquatic products, etc.; The freezer freezer can keep the temperature below -18, which is an ideal storage environment for frozen food; The temperature of refrigerated cold storage is generally between 0 and -5, which is an ideal storage environment for storing eggs, dairy products, meat and other foods.

2.Equipment configuration: (1) Cold storage structure:

The cold storage structure generally includes exterior walls, interior walls and roofs, etc. (2) Cold storage door: Cold storage door can be divided into sliding door, rolling shutter door and folding door.

(3) Cold storage air conditioning: Cold storage air conditioning equipment is mainly used to adjust the temperature and humidity in the cold storage. (4) Cold storage monitoring:

The cold storage monitoring system generally includes temperature sensors, humidity sensors, smoke sensors, etc., which can monitor the temperature, humidity and smoke concentration in the cold storage in real time. It's almost more than 100.

Thank you.