BMW 3 Series fuel tank leakage is not within the scope of the recall, will not be claimed?

On the evening of August 23, 2019, after filling up the gas station with fuel, the fuel tank leaked seriously, and the car did not sound an alarm, which was discovered by the gas station personnel. The next day, I dragged it to the 4S store to check, and it was a problem with the upper part of the fuel tank, and the oil leakage was a serious quality problem of the fuel tank, not caused by human factors.

The BMW 3 Series fuel tank cover is made of multiple layers of material, which may bend if the shrinkage rate is not the same when heated. The outer layer of material shrinks more significantly when exposed to heat, and the surface of the cover plate becomes a dent, causing the torn edges to melt the welded area, resulting in fuel leaking through the cracks in the edges when refilled. The only way to solve the oil leak problem is to replace the entire tank.

At the beginning of 2018, BMW Brilliance, with the intervention of the former General Administration of Quality Supervision, Inspection and Quarantine, announced that from April 2, 2018, BMW Brilliance would recall some BMW 3 Series vehicles manufactured between September 10 and October 31, 2015, a total of 16,504 units. However, according to the information from Cheqq.com, none of the vehicles purchased by the above eight owners are within the scope of the recall announced by BMW Brilliance (see the table below for details). If it is conservatively estimated that there are still hidden dangers in the vehicles produced in June 2016, at least nearly 70,000 BMW 3 Series may also be recruited and need to be recalled.

Some consumers believe that BMW Brilliance deliberately concealed defects in the above-mentioned recall, and the regulatory authorities should severely punish them. <>

<> in accordance with Article 8 of the Regulations on the Administration of Recall of Defective Automobile Products, which came into effect on January 1, 2013, the manufacturer shall recall all defective automobile products in accordance with these Regulations; If the manufacturer fails to implement the recall, the product quality supervision department shall order it to recall in accordance with these regulations. In view of the obvious problem of insufficient batches in the recall of fuel leakage defects in some 2016 BMW 3 Series vehicles initiated by BMW Brilliance in early 2018, we call on the market supervision department to immediately investigate the following issues and disclose them to the public in an appropriate form:

1. Has the 2018 BMW Brilliance recall for fuel leakage defects in some 2016 BMW 3 Series vehicles been completed? What is the proportion of vehicles recalled within the scope of the recall?

2. There are also cases of a large number of fuel leaks in vehicles outside the scope of this recall, is it caused by the same reason described by the manufacturer, or is there another reason? Whatever the reason, why didn't the manufacturer find out and take remedial action in a year and a half?

3. What is the range of the 2016 BMW 3 Series vehicle batches with potential fuel leakage hazards? Can it be published as soon as possible? After all, once an accident occurs at a gas station, the consequences are unimaginable.

4. Based on the investigation results, if it is found that the manufacturer has deliberately concealed defect information, how will the regulatory authorities punish it?

You can change a tubing, then you can also replace the oil tank, you can change the joints of the tubing, you can brush some multi-layer materials.

In this case, you should go to the repair shop to check the damage of the fuel tank, and if the damaged area is relatively small, you can repair it directly.

The best thing to do is to be pulled by a trailer to the repair shop, and it is best to change to a new fuel tank for safety reasons.

In this case, there are several ways to get a refund:

No matter which refund method you choose, be sure to keep the relevant proof of purchase and refueling, and organize your personal vehicle information and relevant information so that you can complete the relevant procedures more quickly when applying for a refund.

BMW III series fuel tank leakage, during the BMW warranty period, the 4S shop is free to replace the fuel tank, all the costs incurred are settled by the 4S shop and the manufacturer, and the owner does not need to pay the cost.

However, during the warranty period, how to calculate the warranty period of the parts after the replacement of the claim, which has to be calculated by the owner and the 4S shop according to the agreement, there is no hard and fast rule in the law, this is the final say of the manufacturer and the 4S shop, and the 4S shop should be confirmed when replacing the fuel tank.

It is difficult to have quality problems with this accessory of the fuel tank, so pay attention to the observation after replacement, and there will be no problem if there is no problem.

The function of the fuel tank is to hold gasoline, and generally there is no problem, so there are no guarantee regulations!

The 3 series fuel tank cap will be deformed at high temperature, resulting in insufficient sealing with the fuel tank mouth, and the manufacturer has recalled this, but some owners are not within the scope of the recall, but this situation also exists. You just go to the car quality network to complain, just upload **.

Hello, the BMW 3 Series is out of gas, and then the vehicle dashboard will light up, similar to the relevant logo of the gas station, and a related sign of this gas station is a reminder that the fuel level is too low. First, when this light is lit. , the vehicle can generally continue to travel about 30 to 50 kilometers.

Second, after this light is lit, it is not recommended to continue driving for a long time. If you drive for a long time, Rong Menghu liquid is easy to cause the problem of oil pump branches. Third, the oil pump inside the fuel tank relies on gasoline to dissipate heat.

If there is too little gasoline, it will affect the heat dissipation performance of the oil pump. In severe cases, it will cause the oil pump to burn out.

Hello friends, BMW fuel tank recall inspection, the fuel tank is no problem in the future, then this depends on how the manufacturer's relevant policies are first, if the manufacturer is conducting relevant recall testing, then if there is no problem, there is no need to replace. Second, if the manufacturer's relevant recall policy is to recall the fuel tank to be replaced, then even if there is no problem with the test, the fuel tank can be required to be replaced. Dibi pants three, this specific also depends on the relevant statements of the 4S store.

1.More than 90% of the causes of oil leakage are caused by the aging of seals (oil seals)! Seals (oil seals) harden over time, that is, they lose their plasticizer over time.

This process is exacerbated by the constant alternating operating temperatures of warm and cold. As a result of this poor process, the seals first begin to shrink, then harden, and finally even break, and oil leaks are inevitable.

2.The traditional maintenance plan is to dismantle and repair the vehicle, and the man-hour cost is often thousands of yuan, as well as the cost of replacement, and the maintenance time is long. At the same time, due to improper operation and other reasons in the process of dismantling and repairing, the vehicle has many other sequelae.

Some oil leaks need to disassemble the engine, so I advise you not to disassemble it easily, the car is not broken, it is repaired! Traditional solutions can be summarized as time-consuming, labor-intensive, and costly.

3.Now the more popular oil leakage solution is to add German Mattie DS directly to the oil, under normal driving, the oil leakage problem will disappear naturally in about 14 days, and the car will not be delayed for dismantling and repairing, so as to avoid the waste of time and money caused by dismantling and repair, and it is easier for the owner to solve the oil leakage problem by himself.

4.It is recommended that 3-5 year old cars be added to Marty DS in advance to prevent oil leakage.

The fuel tank of the BMW 3 Series of the first six models leaks, and the same problem occurs after the replacement of the four-S shop, and you should continue to find the 4S shop to claim and repair.

Article 20 of the Consumer Protection Law Within the validity period of the three guarantees for household automobile products, if the conditions for replacement and return of household automobile products are met, the consumer shall replace or return the goods by the seller with the three guarantees certificate and car purchase invoice.

If a household automobile product has a steering system failure, brake system failure, body cracking or fuel leakage, and the consumer chooses to replace the household automobile product or return the product, the seller shall be responsible for replacing or returning the product free of charge.

During the validity period of the three guarantees of household car products, if one of the following circumstances occurs, and the consumer chooses to replace or return the product, the seller shall be responsible for replacing or returning the product:

In the warranty period of a short period of continuous fuel tank leakage you can also try this, it is estimated that your car has also passed the time, so seize the time to find a 4S shop to replace the fuel tank again, and you can let the 4S shop ask for an extended warranty time.

The reasons for the above situation are as follows:

1. The oil pan gasket is damaged or the screws are loose and leaking;

2. The oil pan oil drain screw plug liner is damaged, leaking or loosening and leaking;

3. Improper assembly of timing gear cover gasket, damage or loose screws and oil leakage;

4. The engine bracket plate is deformed or the gasket is not tightly sealed and leaks oil;

5. The sealing of the valve chamber cover gasket is not strict and the oil leakage;

6. The front oil seal of the crankshaft is damaged and leaks;

7. The oil seal of the crankshaft is damaged and leaks;

8. The oil return thread at the rear end of the crankshaft is blocked by dirt and leaks. Oil leakage due to improper processing of oil return thread or excessive coaxiality between the screw travel continental journal and the oil seal seat hole;

9. The rear cover of the cam bearing is not strict and leaks oil;

10. The rocker arm chamber cover or the lever chamber cover is not strict and leaks oil;

This is going to leak oil.,N20 that 4-cylinder engine.,It's a lot.,Just tighten the screws [If you have a problem with the car, ask the car spine to sell the cherry blossom teasing master.] The 4S shop specializes in digging and erection technicians, and it takes 10 minutes to solve. 】

Hello, the key to the recall of BMW, you can go to the 4S store to consult the receptionist, the recalled parts and material costs are provided by the dealer, do not charge your fees, I hope my help to you, thank you. [If you have a problem with the car, ask the car Daliang remodeler. 4S shop professional technician, 10 minutes to solve. 】